The Preservation of the Exterior of Wooden Buildings, by Allerton S. Cushman, a Project Gutenberg eBook.

Allerton S. Cushman, A. M., Ph. D., Director, In Charge Division Metallurgical Problems.

Henry A. Gardner, Assistant Director, In Charge Division of Paint Technology.

N. Monroe Hopkins, Ph. D., In Charge Division of Electrical Engineering and Electrochemistry.

Chas. A. Crampton, M. D., Ph. G., In Charge Division of Food and Drug Products.

G. W. Coggeshall, Ph. D., In Charge Division of Mill Problems.

Chas. Baskerville, Ph. D., F. C. S., In Charge Technology of the Rarer Elements.

THE PRESERVATION
OF THE
EXTERIOR OF WOODEN BUILDINGS

ALLERTON S. CUSHMAN, Director
THE INSTITUTE OF INDUSTRIAL RESEARCH

HENRY A. GARDNER, Asst. Director
IN CHARGE DIVISION OF PAINT TECHNOLOGY,
THE INSTITUTE OF INDUSTRIAL RESEARCH

PREFACE.

For a number of years the writers have been making a study of industrial problems and have been publishing the information which they have acquired, regarding the value of various structural materials, for the benefit of consumers as well as producers. The Institute of Industrial Research has received so many requests recently for information in regard to just what paints should be selected for the protection and decoration of houses and other buildings that it has seemed best to sum up the subject in the form of a special pamphlet or bulletin. It is only after years of investigation work carried on by the authors, both separately and in co-operation, that any review of the work has seemed possible, for only recently have the results of tests carried on in a number of different localities seemed to justify a definite opinion in regard to the best selection of exterior paints. No attack on any one paint material is here included, but the value of each has been carefully weighed, and the attempt is made to discuss them in the light of experience and knowledge. It is the authors' intention in this bulletin to put into the hands of architects and paint users who may not be thoroughly familiar with the technical properties of paint materials, information which will enable them to make a proper and intelligent selection of paints for the preservation and decoration of the exterior of wooden buildings.

The Preservation of the Exterior of Wooden Buildings

Lumber and its Relation to Paints: The proper choice and treatment of lumber is one of the most important problems which the builder as well as the painter has to face. When about to build a dwelling, barn, or other structure made principally of wood, the question is sure to arise in regard to what variety to select so as to get the maximum service and money value. The locality in which the structure is to be built must often have a bearing upon this question. While it is true that the painting of each type of wood demands the special consideration of the painter, it is also true that the study of paints for wood protection points toward the production of a paint that will give satisfactory results under all conditions and on all grades. It is the writers' opinion that a paint may be made that will be perfectly well suited for the preservation of every species of wood, provided the paint is properly treated in the hands of the skillful and intelligent painter, who can produce lasting results on almost every type by varying the proportion of thinners and oil in the various coats. The painter who uses the same paint on soft pine, and again on hard pine, without making a special study of how to reduce the priming coat for the hard pine, will be likely to get inferior results on the latter. In case of failure, the natural impulse is often to place the blame upon the paint, whereas the real responsibility may rest upon the painter's lack of knowledge.

Note.—For a more detailed account of the lumber question, see "Modern Lumber as a Problem for the Painter," read by John Dewar, at the Convention of Master House Painters' and Decorators' Association of Pennsylvania, January, 1911, Pittsburg, Pa.

Photographs Showing Different Forms of
Decay Exhibited by Improperly
Made Paints

Signs of Paint Failure: Those who are responsible for the care and maintenance of property are familiar with the condition of surface presented by almost all wooden buildings or structures which have been improperly painted with inferior paints. "Chalking" or "flouring" are terms used to describe the condition of a paint surface which has deteriorated within the paint film. The formation of minute fissures, generally spoken of as "checking," as well as the effects best described as cracking, scaling, peeling, and blistering, are other signs of failure which cause paint coatings to present an unsightly appearance, and which point inevitably either to the use of improperly made paints or to improper application. The cause of these conditions is not difficult to understand when even a brief study of the character of the materials entering into the composition of a paint has been made. It is, however, a fortunate circumstance that the proper admixture of different types of pigments enables us to correct the strong tendency exhibited by special pigments to rapidly deteriorate in an oil film. This point will be more fully discussed in a later paragraph.

Requisites of a Good Paint: Progressive manufacturers are aiming to produce a paint which will show, under the widest range of conditions, good hiding power, adhesiveness, freedom from internal strains, permanency of color, relatively high imperviousness to moisture, sufficient elasticity to prevent scaling or cracking when subjected to expansion or contraction, and freedom from the chemical action which results in deep checking or excessive chalking. Such a product as this cannot be attained, in the writers' opinion, by the use of any one pigment in linseed oil. In order to meet all the demands as stated above, there should be in an economical and durable paint a proper percentage of the various pigments which, united, will tend to correct each other's faults, and thus produce a durable paint coating of maximum efficiency.

The Composition of Paints: As is well known, a paint is a mixture of one or more pigments and a vehicle which acts the part of the spreading and binding medium. Up to the present time the vehicle portion of paints has generally been made of linseed oil, admixed with some volatile thinner, such as turpentine. The subject of oils and paint vehicles will be discussed more fully later on.

Physical Properties of Pigments: The pigment portion of a paint for use on barns and farm buildings may, if desired, be composed of properly selected iron oxides or other colored pigments, even containing in some cases a moderately high percentage of silica, clay, or other inert materials, and give perfectly satisfactory results. For the preservation and decoration of dwellings, however, the pigment portion of paints is generally made as a whole or in part of the more expensive white pigments, such as white lead and zinc oxide. The relative values and properties of these white base pigments will now be taken up.

White Leads: White lead, either of the corroded or sublimed type, is perhaps the most generally used of all the white pigments as a paint base. Corroded white lead is a basic carbonate of lead, while sublimed white lead is a basic sulphate of the same metal. Both of these types are white, and admirably adapted as painting materials. They take relatively the same amount of oil and spread easily, producing paint films which are highly opaque and which, therefore, hide efficiently the surface upon which they are placed. Sublimed white lead is a relatively finer pigment than corroded white lead, and seems to show a tendency to chalk to a greater extent upon exposure to the weather. Corroded white lead is more alkaline, however, than sublimed « 7 » white lead, and when used alone with linseed oil generally shows a tendency to chalk to a considerable extent in a short time and to show deep checking, thus permitting the admission of moisture. The alkaline nature of this pigment produces considerable action upon certain tinting colors and results in fading or darkening, when mixed with delicate greens or blues.

The use of white lead has been condemned in some parts of this country as well as abroad, because of its alleged poisonous properties. While it is true that lead poisoning may occasionally occur in some factories where the workman and his conditions are not properly safeguarded, it is, nevertheless, a fact that lead poisoning very seldom occurs among painters of experience and cleanly habits. Carelessness in mixing white lead is, fortunately, a practice almost obsolete among modern painters. The use of paints already ground in oil by means of machinery to a pasty condition, allowing easy working and reducing, obviates the danger of lead poisoning from any such cause as this, even though the percentage of lead in such paints is in preponderance. Recent efforts that have been made by the legislatures of certain States to brand lead paints as poisonous are not only unnecessary, but show a complete ignorance of the problem.

Zinc Pigments: Another pigment which has proved itself of great value to the painter is zinc oxide. The use of this pigment may be said to have almost revolutionized the paint industry of the world, and its increased consumption during the last ten years is sufficient evidence of its value as a painting material. Zinc oxide is produced by oxidation and sublimation of zinc ores and is not only extremely fine, but of great whiteness. It has good hiding power, although not quite so great as that shown by the white leads. It tends to « 8 » produce a glossy surface, making it especially valuable for use on interior work and in enamels. When used alone it has the effect of hardening the oil film in which it is enveloped, and upon long exposure causes cracking and scaling. However, when the sublimed or corroded white leads are properly combined with zinc oxide, a more durable surface is produced, the shortcomings of each pigment being overbalanced by the good properties of the other. The proper combining properties of zinc oxide with white lead may be said to vary between 20 to 55 per cent of zinc oxide for paints designed for exterior use. In the opinion of the authors, lead and zinc pigments in the above percentage, properly blended and ground, make paints of far better wearing value than can be produced with either white lead or zinc oxide used alone.

Zinc Lead: Zinc lead, a pigment sublimed from mixed lead and zinc ores and containing about equal proportions of zinc oxide and lead sulphate intimately combined, as well as leaded zinc, a produce similarly produced, but with the zinc oxide running about 75 per cent, are white base pigments of value, which are used to a considerable extent. They are generally slightly off color, however, and are therefore used most largely in paints which are to be tinted in various colors.

Lithopone: Lithopone, a pigment produced by precipitation, and consisting of zinc sulphide and barium sulphate, is of great value in the manufacture of interior paints. On account of its liability to darken and disintegrate, however, it is seldom used on exterior work, although recent tests have shown that when used in combination with zinc oxide and whiting, it gives very promising results.

Crystalline Pigments and Their Use: Barytes (barium sulphate), silex (silica), whiting (calcium carbonate), gypsum (calcium sulphate), asbestine (silicate of magnesia), and China clay (silicate of alumina) are white crystalline pigments which, when ground in oil, become transparent. All of these pigments possess the property of strengthening a paint film made of white lead and zinc oxide, and often increase the durability of such a paint. Barytes, silica, and China clay are especially valuable for this purpose. Asbestine, because of its needle-like structure and low gravity, prevents settling and acts as a reinforcer of paint films. Whiting or calcium carbonate should be used when zinc oxide is in excess in a paint, so that the hardness of the paint may be overcome.

A white paint must be possessed of sufficient opacity to efficiently hide the surface upon which it is placed, when three coats are applied for new work or two coats for repainting work. Mixtures of the white leads and zinc oxide, with the latter pigment running not over 55 per cent, will easily produce such a result and wear well. It is generally deemed advisable, however, by most manufacturers to take advantage of the excessive opacity of such mixtures, which allows the introduction of moderate percentages of those inert pigments which give greater strength and other desirable features to a paint. The percentage of natural crystalline inert pigments to add to a white paint made of lead and zinc must, however, be moderate and insufficient to detract materially from the hiding power of the paint.

Note.—Pigments such as silica, barytes, China clay, and asbestine are thoroughly inert. Recent investigations have proved that they accelerate the drying of linseed oil, but this is not due to any chemical action they exert, but rather to their physical action in distributing the mass of oil in « 10 » which they are ground, and thus allowing a greater surface to be exposed to the oxygen of the air.

It is also possible that some of the inert pigments may stimulate oxidation by catalytic or contact action, although they are not chemically active in themselves.

White-Paint Formulas: From these conclusions which have come from wide experience in the testing of paints under actual service conditions, there can be recommended to the buyer of paints and to the manufacturer and master painter those machine-mixed paints in white, made by reputable manufacturers, the composition of which will show a mixture of white lead and zinc oxide, with the latter pigment within limits of between 15 to 55 per cent, and especially the same mixtures reinforced with the moderate percentage of crystalline inert pigments referred to above.

Tinted paints possess greater hiding power than white paints, and the above proportions would be somewhat changed for a tinted paint containing any percentage of coloring material. Tinted paints are, moreover, far more serviceable than white paints, as will be shown later.

Mill vs. Paddle: The mixtures under consideration should be ground in linseed oil by the manufacturer, through stone or steel mills, to a very fine condition, as it is only through proper grinding that the pigments can be properly blended. The mixing of paint by hand is, fortunately, to a large extent a thing of the past. The uneven lumping of hand-mixed paints are often the cause of their failure. Such ancient and crude practice should be avoided by every painter, for it is more economical to obtain semi-paste paints, properly ground by machinery, to such a condition that they may be easily broken up and tempered. Such paints may be reduced « 11 » to the proper consistency with oil and volatile thinner for application to any kind of wood.

In the opinion of the writers, a majority of the paints sold by reputable dealers and made by reputable manufacturers in this country are not only made from the best linseed oil and highest-grade pigments obtainable, but are put up in a form ready for the painter to thin down with full oil or turpentine reductions, either for priming work or to be used without reductions for finishing coats. The large metropolitan painter who wishes to make his own tints and shades may, however, prefer to have his mixed pigment paint ground by the manufacturer in heavy paste form for certain purposes.

Results of Field Tests: A careful analysis of the results of field tests which have been carried on in different parts of the country would be far too voluminous for insertion in this bulletin. The official findings of special committees of inspection have already been published in special reports. Whereas there may still remain ground for some difference of opinion in regard to the interpretation of the results obtained on the various test fences, there can be no doubt that considerable information of the highest value has been yielded, both to the producers and consumers of paints. One of the principal results obtained from these tests has led to the opinion expressed above by the writers, that better results can be obtained by a proper mixture of selected pigments than by the use of any one pigment in linseed oil. This conclusion has also been reached by engineers of the United States Navy, and, as a result, the specifications of the Bureau of Yards and Docks for paints made of straight white lead and oil have recently been changed to call for white lead « 12 » combined with upwards of 50 per cent of zinc oxide. Many engineers and master painters have interpreted the results of the tests in the same way, and the attention of the authors has been called to a number of opinions which show that the tendency of demand among those who are properly informed is for a high-grade combination type of paint rather than for any single pigment paint.

Color: The selection of the color for a dwelling or other structure is a matter that depends largely upon the good judgment and taste of the owner, combined with the advice of the painter. One point, however, should be impressed upon the mind of both, namely, that PRACTICALLY ALL SHADES OR TINTS MADE UPON A GOOD WHITE PAINT BASE, THROUGH THE USE OF PERMANENT TINTING COLORS, WILL BETTER WITHSTAND EXPOSURE TO THE ATMOSPHERE THAN THE WHITE BASE USED ALONE. Owing to the cheerful effect produced by the use of white paint on dwellings, a very large quantity of white will continue to be used. If these white paints are designed in line with the suggestions brought out above—that is to say, if the white lead bases are properly reinforced with zinc oxide and other pigmentary materials—better results will undoubtedly be obtained, as far as appearance and durability is concerned, than if white lead had been used alone. The consumer should remember, however, that more durable results will be obtained by the use of tinted paints.

Reductions and Thinners: Turpentine, with its sweet odor, high solvent action, and wonderful oxidizing value, has always taken first place among the volatile liquids used for thinning paints. Wood turpentines, produced from the steam distillation of fine-cut fat pinewood or from the destructive « 13 » distillation of stumpage and sawdust, have been refined in some cases, by elimination of odor and toxic effects, to such purity that they are equally as good as the purest grades of gum turpentine, and their use is bound to increase in the paint industry.

The painter and manufacturer have come to understand that certain grades of asphaltum and paraffine distillates are equally as satisfactory as turpentine for use in paints for exterior purposes. Those volatile oils which are distilled from crude oil with either a paraffine or asphaltum base and possessed of boiling point, flash point, color, and evaporative value approximating similar constants of turpentine, are excellently suited to partly, and in some cases wholly, replace turpentine in exterior paints. A little additional drier added to paints thinned with these materials will cause oxidation to take place in the proper time.

Prominent master painters [A] have shown that benzol, a product obtained from the distillation of coal tar, differing from benzine, a product obtained from the distillation of petroleum, is a valuable thinner to use in the reduction of paints for the priming of resinous lumber such as cypress and yellow pitch pine. The penetrating and solvent value of benzol is high, and it often furnishes a unison between paint and wood that is a prime foundation to subsequent coatings, preventing the usual scaling and sap exudations, which often appear on a painted surface. Because of the great solvent action of benzol, however, this material should never be used in the second and third coatings. These facts will doubtless interest the Southern painter, who has so much wood of a refractory nature to paint.

Oils: The increasing cost of linseed oil has raised the interesting question as to whether or not it is good practice to use an admixture of other oils in connection with it, in high grade paint coatings. Strong differences of opinion will probably be found in regard to this question, and undoubtedly further investigation work is necessary in order to decide it. A number of different oils have been proposed for the purpose, of which, perhaps, soya bean oil is the one which has been most prominently discussed. No definite formulas, however, should be recommended until the results of investigations which are now being carried on are in hand. A systematic series of test panels is now being erected in Washington, D. C., on the grounds of The Institute of Industrial Research, which are designed to gather data covering just this point.

The flax crop conditions have been most discouraging during the past two years, and the natural shortage of seed has caused a rise in the price of linseed oil, which has necessitated a rise in the price of paint. The added protection to be secured, however, through the frequent application of paint far outweighs any increased cost which has been caused by the rise in price of the raw commodities entering into the composition of paint.

*** END OF THE PROJECT GUTENBERG EBOOK THE PRESERVATION OF THE EXTERIOR OF WOODEN BUILDINGS ***

Updated editions will replace the previous one—the old editions will be renamed.

Creating the works from print editions not protected by U.S. copyright law means that no one owns a United States copyright in these works, so the Foundation (and you!) can copy and distribute it in the United States without permission and without paying copyright royalties. Special rules, set forth in the General Terms of Use part of this license, apply to copying and distributing Project Gutenberg™ electronic works to protect the PROJECT GUTENBERG™ concept and trademark. Project Gutenberg is a registered trademark, and may not be used if you charge for an eBook, except by following the terms of the trademark license, including paying royalties for use of the Project Gutenberg trademark. If you do not charge anything for copies of this eBook, complying with the trademark license is very easy. You may use this eBook for nearly any purpose such as creation of derivative works, reports, performances and research. Project Gutenberg eBooks may be modified and printed and given away—you may do practically ANYTHING in the United States with eBooks not protected by U.S. copyright law. Redistribution is subject to the trademark license, especially commercial redistribution.

START: FULL LICENSE

PLEASE READ THIS BEFORE YOU DISTRIBUTE OR USE THIS WORK

To protect the Project Gutenberg™ mission of promoting the free distribution of electronic works, by using or distributing this work (or any other work associated in any way with the phrase “Project Gutenberg”), you agree to comply with all the terms of the Full Project Gutenberg™ License available with this file or online at www.gutenberg.org/license.

Section 1. General Terms of Use and Redistributing Project Gutenberg™ electronic works

1.A. By reading or using any part of this Project Gutenberg™ electronic work, you indicate that you have read, understand, agree to and accept all the terms of this license and intellectual property (trademark/copyright) agreement. If you do not agree to abide by all the terms of this agreement, you must cease using and return or destroy all copies of Project Gutenberg™ electronic works in your possession. If you paid a fee for obtaining a copy of or access to a Project Gutenberg™ electronic work and you do not agree to be bound by the terms of this agreement, you may obtain a refund from the person or entity to whom you paid the fee as set forth in paragraph 1.E.8.

1.B. “Project Gutenberg” is a registered trademark. It may only be used on or associated in any way with an electronic work by people who agree to be bound by the terms of this agreement. There are a few things that you can do with most Project Gutenberg™ electronic works even without complying with the full terms of this agreement. See paragraph 1.C below. There are a lot of things you can do with Project Gutenberg™ electronic works if you follow the terms of this agreement and help preserve free future access to Project Gutenberg™ electronic works. See paragraph 1.E below.

1.C. The Project Gutenberg Literary Archive Foundation (“the Foundation” or PGLAF), owns a compilation copyright in the collection of Project Gutenberg™ electronic works. Nearly all the individual works in the collection are in the public domain in the United States. If an individual work is unprotected by copyright law in the United States and you are located in the United States, we do not claim a right to prevent you from copying, distributing, performing, displaying or creating derivative works based on the work as long as all references to Project Gutenberg are removed. Of course, we hope that you will support the Project Gutenberg™ mission of promoting free access to electronic works by freely sharing Project Gutenberg™ works in compliance with the terms of this agreement for keeping the Project Gutenberg™ name associated with the work. You can easily comply with the terms of this agreement by keeping this work in the same format with its attached full Project Gutenberg™ License when you share it without charge with others.

1.D. The copyright laws of the place where you are located also govern what you can do with this work. Copyright laws in most countries are in a constant state of change. If you are outside the United States, check the laws of your country in addition to the terms of this agreement before downloading, copying, displaying, performing, distributing or creating derivative works based on this work or any other Project Gutenberg™ work. The Foundation makes no representations concerning the copyright status of any work in any country other than the United States.

1.E. Unless you have removed all references to Project Gutenberg:

1.E.1. The following sentence, with active links to, or other immediate access to, the full Project Gutenberg™ License must appear prominently whenever any copy of a Project Gutenberg™ work (any work on which the phrase “Project Gutenberg” appears, or with which the phrase “Project Gutenberg” is associated) is accessed, displayed, performed, viewed, copied or distributed:

This eBook is for the use of anyone anywhere in the United States and most other parts of the world at no cost and with almost no restrictions whatsoever. You may copy it, give it away or re-use it under the terms of the Project Gutenberg License included with this eBook or online at www.gutenberg.org. If you are not located in the United States, you will have to check the laws of the country where you are located before using this eBook.

1.E.2. If an individual Project Gutenberg™ electronic work is derived from texts not protected by U.S. copyright law (does not contain a notice indicating that it is posted with permission of the copyright holder), the work can be copied and distributed to anyone in the United States without paying any fees or charges. If you are redistributing or providing access to a work with the phrase “Project Gutenberg” associated with or appearing on the work, you must comply either with the requirements of paragraphs 1.E.1 through 1.E.7 or obtain permission for the use of the work and the Project Gutenberg™ trademark as set forth in paragraphs 1.E.8 or 1.E.9.

1.E.3. If an individual Project Gutenberg™ electronic work is posted with the permission of the copyright holder, your use and distribution must comply with both paragraphs 1.E.1 through 1.E.7 and any additional terms imposed by the copyright holder. Additional terms will be linked to the Project Gutenberg™ License for all works posted with the permission of the copyright holder found at the beginning of this work.

1.E.4. Do not unlink or detach or remove the full Project Gutenberg™ License terms from this work, or any files containing a part of this work or any other work associated with Project Gutenberg™.

1.E.5. Do not copy, display, perform, distribute or redistribute this electronic work, or any part of this electronic work, without prominently displaying the sentence set forth in paragraph 1.E.1 with active links or immediate access to the full terms of the Project Gutenberg™ License.

1.E.6. You may convert to and distribute this work in any binary, compressed, marked up, nonproprietary or proprietary form, including any word processing or hypertext form. However, if you provide access to or distribute copies of a Project Gutenberg™ work in a format other than “Plain Vanilla ASCII” or other format used in the official version posted on the official Project Gutenberg™ website (www.gutenberg.org), you must, at no additional cost, fee or expense to the user, provide a copy, a means of exporting a copy, or a means of obtaining a copy upon request, of the work in its original “Plain Vanilla ASCII” or other form. Any alternate format must include the full Project Gutenberg™ License as specified in paragraph 1.E.1.

1.E.7. Do not charge a fee for access to, viewing, displaying, performing, copying or distributing any Project Gutenberg™ works unless you comply with paragraph 1.E.8 or 1.E.9.

1.E.8. You may charge a reasonable fee for copies of or providing access to or distributing Project Gutenberg™ electronic works provided that:

• You pay a royalty fee of 20% of the gross profits you derive from the use of Project Gutenberg™ works calculated using the method you already use to calculate your applicable taxes. The fee is owed to the owner of the Project Gutenberg™ trademark, but he has agreed to donate royalties under this paragraph to the Project Gutenberg Literary Archive Foundation. Royalty payments must be paid within 60 days following each date on which you prepare (or are legally required to prepare) your periodic tax returns. Royalty payments should be clearly marked as such and sent to the Project Gutenberg Literary Archive Foundation at the address specified in Section 4, “Information about donations to the Project Gutenberg Literary Archive Foundation.”
• You provide a full refund of any money paid by a user who notifies you in writing (or by e-mail) within 30 days of receipt that s/he does not agree to the terms of the full Project Gutenberg™ License. You must require such a user to return or destroy all copies of the works possessed in a physical medium and discontinue all use of and all access to other copies of Project Gutenberg™ works.
• You provide, in accordance with paragraph 1.F.3, a full refund of any money paid for a work or a replacement copy, if a defect in the electronic work is discovered and reported to you within 90 days of receipt of the work.
• You comply with all other terms of this agreement for free distribution of Project Gutenberg™ works.

1.E.9. If you wish to charge a fee or distribute a Project Gutenberg™ electronic work or group of works on different terms than are set forth in this agreement, you must obtain permission in writing from the Project Gutenberg Literary Archive Foundation, the manager of the Project Gutenberg™ trademark. Contact the Foundation as set forth in Section 3 below.

1.F.

1.F.1. Project Gutenberg volunteers and employees expend considerable effort to identify, do copyright research on, transcribe and proofread works not protected by U.S. copyright law in creating the Project Gutenberg™ collection. Despite these efforts, Project Gutenberg™ electronic works, and the medium on which they may be stored, may contain “Defects,” such as, but not limited to, incomplete, inaccurate or corrupt data, transcription errors, a copyright or other intellectual property infringement, a defective or damaged disk or other medium, a computer virus, or computer codes that damage or cannot be read by your equipment.

1.F.2. LIMITED WARRANTY, DISCLAIMER OF DAMAGES - Except for the “Right of Replacement or Refund” described in paragraph 1.F.3, the Project Gutenberg Literary Archive Foundation, the owner of the Project Gutenberg™ trademark, and any other party distributing a Project Gutenberg™ electronic work under this agreement, disclaim all liability to you for damages, costs and expenses, including legal fees. YOU AGREE THAT YOU HAVE NO REMEDIES FOR NEGLIGENCE, STRICT LIABILITY, BREACH OF WARRANTY OR BREACH OF CONTRACT EXCEPT THOSE PROVIDED IN PARAGRAPH 1.F.3. YOU AGREE THAT THE FOUNDATION, THE TRADEMARK OWNER, AND ANY DISTRIBUTOR UNDER THIS AGREEMENT WILL NOT BE LIABLE TO YOU FOR ACTUAL, DIRECT, INDIRECT, CONSEQUENTIAL, PUNITIVE OR INCIDENTAL DAMAGES EVEN IF YOU GIVE NOTICE OF THE POSSIBILITY OF SUCH DAMAGE.

1.F.3. LIMITED RIGHT OF REPLACEMENT OR REFUND - If you discover a defect in this electronic work within 90 days of receiving it, you can receive a refund of the money (if any) you paid for it by sending a written explanation to the person you received the work from. If you received the work on a physical medium, you must return the medium with your written explanation. The person or entity that provided you with the defective work may elect to provide a replacement copy in lieu of a refund. If you received the work electronically, the person or entity providing it to you may choose to give you a second opportunity to receive the work electronically in lieu of a refund. If the second copy is also defective, you may demand a refund in writing without further opportunities to fix the problem.

1.F.4. Except for the limited right of replacement or refund set forth in paragraph 1.F.3, this work is provided to you ‘AS-IS’, WITH NO OTHER WARRANTIES OF ANY KIND, EXPRESS OR IMPLIED, INCLUDING BUT NOT LIMITED TO WARRANTIES OF MERCHANTABILITY OR FITNESS FOR ANY PURPOSE.

1.F.5. Some states do not allow disclaimers of certain implied warranties or the exclusion or limitation of certain types of damages. If any disclaimer or limitation set forth in this agreement violates the law of the state applicable to this agreement, the agreement shall be interpreted to make the maximum disclaimer or limitation permitted by the applicable state law. The invalidity or unenforceability of any provision of this agreement shall not void the remaining provisions.

1.F.6. INDEMNITY - You agree to indemnify and hold the Foundation, the trademark owner, any agent or employee of the Foundation, anyone providing copies of Project Gutenberg™ electronic works in accordance with this agreement, and any volunteers associated with the production, promotion and distribution of Project Gutenberg™ electronic works, harmless from all liability, costs and expenses, including legal fees, that arise directly or indirectly from any of the following which you do or cause to occur: (a) distribution of this or any Project Gutenberg™ work, (b) alteration, modification, or additions or deletions to any Project Gutenberg™ work, and (c) any Defect you cause.

Section 2. Information about the Mission of Project Gutenberg™

Project Gutenberg™ is synonymous with the free distribution of electronic works in formats readable by the widest variety of computers including obsolete, old, middle-aged and new computers. It exists because of the efforts of hundreds of volunteers and donations from people in all walks of life.

Volunteers and financial support to provide volunteers with the assistance they need are critical to reaching Project Gutenberg™’s goals and ensuring that the Project Gutenberg™ collection will remain freely available for generations to come. In 2001, the Project Gutenberg Literary Archive Foundation was created to provide a secure and permanent future for Project Gutenberg™ and future generations. To learn more about the Project Gutenberg Literary Archive Foundation and how your efforts and donations can help, see Sections 3 and 4 and the Foundation information page at www.gutenberg.org.

Section 3. Information about the Project Gutenberg Literary Archive Foundation

The Project Gutenberg Literary Archive Foundation is a non-profit 501(c)(3) educational corporation organized under the laws of the state of Mississippi and granted tax exempt status by the Internal Revenue Service. The Foundation’s EIN or federal tax identification number is 64-6221541. Contributions to the Project Gutenberg Literary Archive Foundation are tax deductible to the full extent permitted by U.S. federal laws and your state’s laws.

The Foundation’s business office is located at 809 North 1500 West, Salt Lake City, UT 84116, (801) 596-1887. Email contact links and up to date contact information can be found at the Foundation’s website and official page at www.gutenberg.org/contact

Section 4. Information about Donations to the Project Gutenberg Literary Archive Foundation

Project Gutenberg™ depends upon and cannot survive without widespread public support and donations to carry out its mission of increasing the number of public domain and licensed works that can be freely distributed in machine-readable form accessible by the widest array of equipment including outdated equipment. Many small donations ($1 to $5,000) are particularly important to maintaining tax exempt status with the IRS.

The Foundation is committed to complying with the laws regulating charities and charitable donations in all 50 states of the United States. Compliance requirements are not uniform and it takes a considerable effort, much paperwork and many fees to meet and keep up with these requirements. We do not solicit donations in locations where we have not received written confirmation of compliance. To SEND DONATIONS or determine the status of compliance for any particular state visit www.gutenberg.org/donate.

While we cannot and do not solicit contributions from states where we have not met the solicitation requirements, we know of no prohibition against accepting unsolicited donations from donors in such states who approach us with offers to donate.

International donations are gratefully accepted, but we cannot make any statements concerning tax treatment of donations received from outside the United States. U.S. laws alone swamp our small staff.

Please check the Project Gutenberg web pages for current donation methods and addresses. Donations are accepted in a number of other ways including checks, online payments and credit card donations. To donate, please visit: www.gutenberg.org/donate.

Section 5. General Information About Project Gutenberg™ electronic works

Professor Michael S. Hart was the originator of the Project Gutenberg™ concept of a library of electronic works that could be freely shared with anyone. For forty years, he produced and distributed Project Gutenberg™ eBooks with only a loose network of volunteer support.

Project Gutenberg™ eBooks are often created from several printed editions, all of which are confirmed as not protected by copyright in the U.S. unless a copyright notice is included. Thus, we do not necessarily keep eBooks in compliance with any particular paper edition.

Most people start at our website which has the main PG search facility: www.gutenberg.org.

This website includes information about Project Gutenberg™, including how to make donations to the Project Gutenberg Literary Archive Foundation, how to help produce our new eBooks, and how to subscribe to our email newsletter to hear about new eBooks.

The Project Gutenberg eBook of The Preservation of the Exterior of Wooden Buildings

THE PRESERVATION
OF THE
EXTERIOR OF WOODEN BUILDINGS

ALLERTON S. CUSHMAN, Director
THE INSTITUTE OF INDUSTRIAL RESEARCH

HENRY A. GARDNER, Asst. Director
IN CHARGE DIVISION OF PAINT TECHNOLOGY,
THE INSTITUTE OF INDUSTRIAL RESEARCH

PREFACE.